Abstract
The aim of this study was to select a support medium for an anaerobic biofilm fluidized bed reactor (AFBR) for waste water treatment. Six materials, shale, pumice, porous glass, quartz sand, activated carbon and anthracite were used as carriers for the biofilm. The reactors were operated in parallel for several months with vapour condensate from a sulfite cellulose process as feed. The criteria used for the evaluation were: a) Reproducibility of the reactor performance, b) performance of the different carriers under various loading rates, c) stability against toxic shock loadings using 2,4,6-trichlorophenol (TCP) as toxicant, d) recovery capacity after intoxication and starvation, e) adsorption/desorption behavior of the carriers.
A comparison between four runs showed good reproducibility of the steady state removal rates. The performance of the reactors and the stability of the degradation rates were tested for a range of loading conditions. Unbuffered, buffered and pH controlled conditions were compared. The pumice carrier was best with respect to the degradation rate achieved per carrier mass. The response of the reactors to massive TCP step loadings was tested. Loadings less than 1.5 kg TCP/m3d resulted in initially normal gas production rates for all the systems, except the activated carbon, whose gas production was partially inhibited from the start. After increasing the load to 1.5 kg TCP/m3d the gas production rates of all the other reactors fell abruptly to zero. Restarting after 2 months, all reactors showed methanogenic activity without requiring new inoculum.
Adsorption and desorption experiments with TCP showed that only the anthracite and activated carbon adsorbed appreciable amounts. The activated carbon had the greatest adsorption capacity but did not release the TCP by desorption, as did the anthracite.
A bicomponent (pumice and anthracite) carrier mixture was compared in biological experiments with pumice and anthracite carrier alone, with and without TCP loading. The pumice and the carrier-mix performed equally well under non-toxic-loading conditions. With TCP toxic loading, the performance of the anthracite was superior. The anthracite carrier could be regenerated, owing mainly to its capacity for desorption.
Similar content being viewed by others
References
Henze, M.; Harremoes, P.: Anaerobic treatment of wastewater in fixed film reactors- a literature review. Water Sci. Technol. 15 (1983) 8/9, 1/101
Hickey, R. F.; Goodwin S.: Anaerobic processes. J. Water Pollut. Control Fed. 61 (1989) 814/821
Yoda, M.; Shin, S. W.; Watanabe, A.; Kitigawa, W.; Miyaji, Y.: Anaerobic fluidized bed treatment with a steady-state biofilm. Water Sci. Technol. 19 (1987) 7/8, 287/298
Huysman, P.; van Meenen, P.; van Assche, P.; and Verstraete, W.: Factors affecting the colonisation of non porous and porous packing materials in model upflow methane reactors. Biotechnol. Lett. 5 (1983) 643/647
Stonach, S. M.; Diaz-Baez, M. C.; Rudd, T.; Lester, J. N.: Factors affecting biomass attachment during startup and operation of anaerobic fluidized beds. Biotechnol. Bioeng. 30 (1987) 611/620
Kuroda, M.; Yuzawa, M.; Sakakibara, Y.; Okamura, M.: Methanogenic bacteria adhered to solid support (film formation kinetic). Water Res. 22 (1988) 653/656
Gorris, L. G. M.; van Deursen, J. M. A.; van der Drift, C.; Vogels, G. D.: Biofilm development in laboratory methanogenic fluidized bed reactors. Biotechnol. Bioeng. 33 (1989) 687/693
Albagnac, G.: Biomass retention in advanced anaerobic reactors. Water Sci. Technol. 22 (1990) 1/2, 17/23
Murray, W. D.; van den Berg, L.: Effect of support material on the development of microbial fixed films converting acetic acid to methane. J. Appl. Bacteriol. 51 (1981) 257/267
Rouxhet, P. G.; Mozes, N.: Physical chemistry of the interface between attached microorganisms and their support. Water Sci. Technol. 22 (1990) 1/2, 1/16
Mozes, N.; Leonard, A. J.; Rouxet, P. G.: On the relations between the elemental surface composition of yeasts and bacteria and their charge and hydrophobicity. Biochim. Biophys. Acta 945 (1988) 324/334
Petrozzi, S.; Dunn, I. J.; Heinzle, E.; Kut, O. M.: Carrier influence in anaerobic biofilm fluidized beds for treating vapor condensate from the sulfite cellulose process. Can. J. Chem. Eng. 69 (1991) 527/53
Mol, N.; Heinzle, E.; Petrozzi, S.; Kut, O. M.; Dunn, I. J.: Carrier influence for the treatment of industrial wastewaters in anaerobic biofilm fluidized bed reactors. Recent Advances in Biotechnology. Ed. F. Vardar-Sukan and S. S. Sukan. Kluwer Academic Publishers. The Netherlands. (1992) 419/424
Scaramelli, A. B.; Di Giano, F.: Upgrading the activated sludge system by addition of powdered activated carbon. Water Sewage Works 120 (1970) 90/98
Robertaccio, F. L.: Powdered activated carbon addition to biological reactors. Ph.D. thesis, Univ. of Delaware (1976)
Adams, A. D.: Improving activated sludge treatment with powdered activated carbon. Eng. Bull. Purdue Univ. Eng. Ext. Ser. 142 (1973) 1, 1/11
Kim, B. R.; Cognata, M. B.: PAC Addition as a means of regenerating GAC in a GAC fluidized bed reactor. Water Res. 24 (1990) 103/109
Kim, B. R.; Chian, E. S. K.; Cross, W. H.; Cheng, S.-S.: Adsorption, desorption, and bioregeneration in an anaerobic, granular activated carbon reactor for the removal of phenols. J. Water Pollut. Control Fed. 58 (1986) 35/41
Kim, B. R.; Matz, M. J.; Lipari, F.: Treatment of a metal-cutting fluids waste-water using an anaerobic GAC fluidized-bed reactor. J. Water Pollut. Control Fed. 61 (1989) 1430/1435
Suidan, M. T.; Strubler, C. E.; Kao, S. W.; Pfeffer, J. T. P.: Traetment of coal gasification wastewater with anaerobic filter technology. J. Wat. Pollut. Control Fed. 55 (1983) 1263/1270
Perotti, A. E.; Rodman, C. A.: Factors involved with biological regeneration of activated carbon. AICHE Symposium Series 70 (1974) 144, 316/325
Zhang, X.; Wang, Z.; Gu, X.: Simple combination of biodegradation and carbon adsorption — the mechanism of the biological activated carbon process. Water Res. 25 (1991) 165/172
Petrozzi, S.; Mol, N.; Dunn, I. J.: Determining specific biomass activity in anaerobic wastewater treatment processes. Bioprocess Eng. 8 (1992) 55/60
Monzambe, K. M.; Navaeu, H. P.; Nyns, E.-J.; Bogaert, N.; Bühler, H.: Problematics and stability of on-line pH measurements in anaerobic environments: the jellied combined electrode. Biotechnol. Bioeng. 31 (1988) 659/665
Ettinger, M. B.; Ruchhof, C. C.; Lishka, R. J.: Sensitive 4-aminoantipyrine method for phenolic compounds. Anal. Chem. 23 (1951) 1783/1788
Vidic, R. D.; Suidan, M. T.: Role of dissolved oxygen on the adsorptive capacity of activated carbon for synthetic and natural organic matter. Environ. Sci. Technol. 25 (1991) 1612/1618
Bishop, D. F.; O'Farrel, T. P.; Stamberg, J.: Physical-chemical treatment of municipal wastewater. J. Water Pollut. Control Fed. 44 (1972) 361/371
Bayley, R. W.; Thomas E. V.; Cooper, P. F.: Some problems associated with treatment of sewage by non-biological processes. Progr. Water Technol. 1 (1972) 119/132
Fahmy, M. K.: Treatment of sulphite pulp bleaching effluents in anaerobic/aerobic fluidized biofilm reactors. Diss. ETH 9730 (1992)
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Petrozzi, S., Kut, O.M. & Dunn, I.J. Protection of biofilms against toxic shocks by the adsorption and desorption capacity of carriers in anaerobic fluidized bed reactors. Bioprocess Eng. 9, 47–59 (1993). https://doi.org/10.1007/BF00369032
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF00369032