Skip to main content
Log in

Brittle fracture and spinnability of viscous materials

  • Originals
  • Published:
Rheologica Acta Aims and scope Submit manuscript

Conclusion

In both cases, brittle fracture and dropping breakdown, only very little deformation or elongation was observed in the experiments mentioned above, and limiting conditions were obtained reproducibly with respect to rate of extension and temperature. The brittle limits give the condition where the viscous resistance due to locally concentrated stress, i. e. the grip effect (5) exceeds cohesion of the materials, and development of the surface of separation is followed. At the dropping limits, the viscosities of the liquids may be too small to resist shrinking by surface tension with respect to the rate of extension. Although the theory of spinnability proposed here may be only tentative, it can be pointed out that surface tension plays some important role in spinning of viscous liquids of lower molecules. Concerning higher molecules, rubber-like elasticity as well as viscosity may become more important (6).

Zusammenfassung

Für beide Fälle, spröden Bruch und stufenweiser Bruch, wurde nur sehr geringe Deformation oder Verlängerung beobachtet und Grenzbedingungen hinsichtlich Dehnungsgeschwindigkeit und Temperatur reproduzierbar erhalten. Die Bruchgrenzen geben die Bedingungen, bei denen der viskose Widerstand entsprechend den lokalen Spannungskonzentrationen, d. h. entsprechend den „grip“-Effekt die Kohäsion des Materials übersteigt, und die Entwickelung der Trennfläche wird verfolgt. Bei der Grenzbelastung für das Absinken der Spannung mag die Viskosität der Flüssigkeiten zu gering sein, um dem Schrumpfen durch Oberflächenspannung im Vergleich mit der Dehnungsgeschwindigkeit entgegen zu wirken. Obgleich die Theorie der Spinnbarkeit, hier vorgeschlagen, nur einen Versuch darstellt, kann behauptet werden, daß die Oberflächenspannung beim Spinnen viskoser Flüssigkeiten mit kleineren Molekülen eine wichtige Rolle spielt. Für höhermolekulare Substanzen wird neben der Viskosität auch die Gummielastizität ausschlaggebend.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Gotoh, R. et al., Bull. Inst. Chem. Res.35, 26 (1957).

    Google Scholar 

  2. Reiner, M., Deformation and Flow (London 1949) 296.

  3. Alfrey, T., Mechanical Behavior of High Polymers (New York 1948) 490.

  4. Hirai, N., J. Chem. Soc. Japan75, 1021 (1954).

    Google Scholar 

  5. Reiner, M., Research on the Rheological Properties of Bitumen and Asphalt (Jerusalem 1948) 5.

  6. Shishido, S. andY. Ito, J. Chem. Soc. Japan78, 203, 608 (1957).

    Google Scholar 

Download references

Author information

Authors and Affiliations

Authors

Rights and permissions

Reprints and permissions

About this article

Cite this article

Gotoh, R., Aida, H., Hayashi, S. et al. Brittle fracture and spinnability of viscous materials. Rheol Acta 1, 213–215 (1958). https://doi.org/10.1007/BF01968869

Download citation

  • Received:

  • Issue Date:

  • DOI: https://doi.org/10.1007/BF01968869

Keywords

Navigation