Skip to main content
SpringerLink
Log in

Use of frozen cranial vault bone allografts in the repair of extensive cranial bone defects

  • Operative Technique
  • Published:
Acta Neurochirurgica Aims and scope Submit manuscript

Summary

In cranioplasty complexity is proportional to the size of the defect, particularly if greater than 50 cm2. If the patient's own bone flap is not available, allogenic frozen bone graft can be used instead.

Between June 1990 and June 1995 twenty cranioplasties with allogenic frozen bone grafts were performed. Age of patients ranged between 23 and 63 years (average 38.4 years). Male/female ratio was 2 ∶ 1.7. Size of craniectomy ranged between 65 and 150 cm2 (average 83.3 cm2). Follow-up ranged between 10 and 58 months (average 41 months).

Donors were tested to rule out transmissible diseases, infections, sepsis and/or cancer. Bone grafts were removed under aseptic conditions, microbiological cultures were taken, wrapped in a gauze soaked with Gentamicin sulphate and Bacitracin, sealed in three sterilised vinyl plastic bags, and stored in a deep freezer for a minimum of 30 days (range 36–93 days, average 67 days), at a temperature of −80 °C.

Grafts were placed in the defect after a step was carved on its borders to facilitate the contact between host and graft. Vancomycin 1 g. IV/12 hours and Ceftriaxone 1 g. IV/12 hours were administered for five days.

Grafts were covered by means of scalp flaps. Only one required a musculocutaneous free flap. None was exposed, extruded or had to be removed.

Plain skull X-ray studies showed progressive remodelling of the grafts. Partial resorption was observed in two (2/20, 10%) and loss of thickness in another 3/20 (15%), but with no changes in the contour.

Biopsies were taken in 3/20 (15%) cases at a second surgical procedure. Areas of osteoclastic resorptive activity mixed with others of osteoblastic bone apposition, showed replacement with new bone.

We conclude that cranial vault frozen allografts are a good alternative to autologous bone when the latter is absent or not present in sufficient amount.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. American Association of Tissue Banks (1984) Standards for Tissue Banking. Arlington, Virginia, American Association of Tissue Banks

    Google Scholar 

  2. American Association of Tissue Banks (1987) Technical Manual for Tissue Banking. Arlington, Virginia, American Association of Tissue Banks

    Google Scholar 

  3. Bright RW, Smarsh JD, Gambil VM (1981) Sterilization of human bone by irradiation. In: Friedlaender GE, Mankin HJ, Sell KW (eds) Osteochondral allografts: biology, banking and clinical applications. Little Brown, Boston, pp 223–232

    Google Scholar 

  4. Burwell RG (1976) The fate of freeze dried bone allograft. Transplant Proc 8 [Suppl 1]: 95–99

    PubMed  Google Scholar 

  5. Chalmers J (1959) Transplantation immunity in bone homografting. J Bone Joint Surg 41B: 160–179

    Google Scholar 

  6. Christian JM, Peterson LJ (1982) Frozen femoral head allogenic bone grafts for orthognatic surgery. J Oral Maxillofac Surg 40(10): 635–639

    PubMed  Google Scholar 

  7. Converse JM (1950) Restoration of facial contour by bone grafts introduced through the oral cavity. Plast Reconstr Surg 6: 295–300

    PubMed  Google Scholar 

  8. Conway B, Tomford W, Mankin HJ, Hirsch MS, Schooley RT (1991) Radiosensitivity of HIV−1: potential application to sterilization of bone allografts. AIDS 5: 608–609

    PubMed  Google Scholar 

  9. Dahlin C, Alberius P, Linde A (1991) Osteopromotion for cranioplasty. An experimental study in rats using a membrane technique. J Neurosurg 74(3): 487–491

    PubMed  Google Scholar 

  10. Eastlund T (1995) Infectious disease transmission through cell, tissue, and organ transplantation: reducing the risk through donor selection. Cell Transplant 4(5): 455–477

    PubMed  Google Scholar 

  11. Edwards MSB, Ousterhout DK (1987) Autogenic skull bone grafts to reconstruct large complex skull defects in children and adolescents. Neurosurgery 20: 273–280

    PubMed  Google Scholar 

  12. Elves MW (1974) Humoral immune response to allografts of bone. Int Arch Allergy Appl Immunol 47: 708–711

    PubMed  Google Scholar 

  13. Elliott H, Scott HJ (1951) The bone-bank in neurosurgery. Br J Surg 39: 31–34

    PubMed  Google Scholar 

  14. Ellis E III, Sinn D (1993) Use of homologous bone in maxillofacial surgery. J Oral Maxillofac Surg 51: 1181–1193

    PubMed  Google Scholar 

  15. Enneking WF (1962) Immunologic aspects of bone transplantation. South Med J 55: 894–899

    PubMed  Google Scholar 

  16. Esmonde T, Lueck CJ, Symond L, Duchen LW, Will RG (1993) Creutzfeld-Jakob disease and lyophilised dura mater grafts: report of two cases. J Neurol Neurosurg Psychiatry 56(9): 999–1000

    PubMed  Google Scholar 

  17. Friedlaender GE, Strong DM, Sell KW (1976) Studies on the antigenicity of bone. I. Freeze-dried and deep frozen bone allografts in rabbits. J Bone Joint Surg 58A: 854–858

    Google Scholar 

  18. Goldberg VM, Powell A, Shaffer JW, Zika J, Bos GD, Heiple KG (1985) Bone grafting: role of histocompatibility in transplantation. J Orthop Res 3(4): 389–404

    PubMed  Google Scholar 

  19. Goldberg VM, Stevenson L (1987) Natural history of autografts and allografts. Clin Orthop Re1 Res 225: 7–16

    Google Scholar 

  20. Herron LD, Newman MH (1989) The failure of ethylene oxide gas-sterilized freeze-dried bone graft for thoracic and lumbar fusion. Spine 14: 496–500

    PubMed  Google Scholar 

  21. Horsburg CR, Ou CY, Jason J, Holmberg SD, Longini IM, Schable C, Mayer K, Lifson AR, Schochetman G, Ward JW (1989) Duration of human immunodeficiency virus infection before detection of antibody. Lancet 2(8664): 637–640

    PubMed  Google Scholar 

  22. Inclan A (1942) The use of preserved bone grafts in orthopaedic surgery. J Bone Joint Surg 24: 81–96

    Google Scholar 

  23. Isaksson S, Alberius P, Klinge B, Jonsson J, Hallberg E, Wendel M (1992) Regenerative response to membranous and enchondral lyophilized allogeneic bone in rabbit skull defects. Scand J Plast Reconstr Surg Hand Surg 26(2): 147–153

    PubMed  Google Scholar 

  24. Joffe JM, McDermott PJ, Linney AD, Mosse CA, Harris M (1992) Computer-generated titanium cranioplasty: report of a new technique for repairing skull defects. Br J Neurosurg 6(4): 343–350

    PubMed  Google Scholar 

  25. Kreutz FP, Hyatt GW, Turner TC, Bassett AL (1951) The preservation and clinical use of freezed-dried bone. J Bone Joint Surg 33A: 863–872

    Google Scholar 

  26. Kulali A, Kayaalp S (1991) Single-table autogenous calvarial grafting for cranioplasty. J Craniomaxillofac Surg 19(5): 208–211

    PubMed  Google Scholar 

  27. Langer F, Czitrom A, Pritzker KP, Gross AE (1975) The immunogenicity of fresh and frozen allogenic bone. J Bone Joint Surg 57(2): 216–220

    PubMed  Google Scholar 

  28. Lee C, Antonyshyn OM, Forrest CR (1995) Cranioplasty: indications, technique, and early results of autogenous split skull cranial vault reconstruction. J Craniomaxillofac Surg 23(3): 133–142

    PubMed  Google Scholar 

  29. Manning CW (1960) A bone bank. Proc R Soc Med 53: 935–940

    PubMed  Google Scholar 

  30. Manson PN, Crawley WA, Hoopes JE (1986) Frontal cranioplasty: risk factors and choice of cranial vault reconstructive material. Plast Reconstr Surg 77: 888–900

    PubMed  Google Scholar 

  31. Martinez-Lage JF, Poza M, Sola J, Tortosa JG, Brown P, Cervenakova L, Esteban JA, Mendoza A (1994) Accidental transmission of Creutzfeldt-Jakob disease by dural cadaveric grafts. J Neurol Neurosurg Psychiatry 57(9): 1091–1094

    PubMed  Google Scholar 

  32. Marx RE, Kline SN, Johnson RP, Malinin TI, Mattheus JG 2d, Gambill V (1981) The use of freeze-dried allogenic bone in oral and maxillofacial surgery. J Oral Surg 39(4): 264–274

    PubMed  Google Scholar 

  33. Massulo C, Pocchiari MA, Macchi G, Alema G, Piazza G, Panzera MA (1989) Transmission of Creutzfeldt-Jakob disease by dural cadaveric graft. J Neurosurg 71: 954–955

    PubMed  Google Scholar 

  34. Nisbet TJ, MacDonaldson Y, Bisbara SN (1989) Creutzfeldt-Jakob disease in a second patient who received a cadaveric dura mater graft. JAMA 261: 1118

    Google Scholar 

  35. Odom GL, Woodhall B, Wrenn FR (1952) The use of refrigerated autogenous bone flaps for cranioplasty. J Neurosurg 9: 606–610

    PubMed  Google Scholar 

  36. Osawa M, Hara H, Ichinose Y, Koyama T, Kobayashi S, Sugita Y (1990) Cranioplasty with frozen and autoclaved bone flaps. Acta Neurochir (Wien) 102: 38–41

    Google Scholar 

  37. Prolo DJ, Oklund SA (1984) Composite autogenic human cranioplasty: frozen skull supplemented with fresh iliac corticocancellous bone. Neurosurgery 15: 846–851

    PubMed  Google Scholar 

  38. Prolo DJ, Rodrigo JJ (1985) Contemporary bone graft physiology and surgery. Clin Orthop 200: 322–342

    PubMed  Google Scholar 

  39. Prolo DJ, Oklund SA (1991) The use of bone grafts and alloplastic materials in cranioplasty. Clin Orthop 268: 270–278

    PubMed  Google Scholar 

  40. Ray BS, Parsons H (1947) The replacement of free bone plates in routine craniotomies. J Neurosurg 4: 299–308

    Google Scholar 

  41. Sanz J, Elejabeitia E, García-Tutor E, Bazán A, Palom V (1996) The viability of cryopreserved onlay cranial bone allografts. Ann Plast Surg 36(4): 370–379

    PubMed  Google Scholar 

  42. Simonds RJ, Homberg SD, Hurwitz RL, Coleman TR, Bottensfield S, Conley LJ, Kohlenberg SH, Castro KG, Dahan BA, Schable CA, Rayfield MA, Rogers MF (1992) Transplantation of human immunodeficiency virus Type I from a seronegative organ and tissue donor. N Engl J Med 326(11): 726–732

    PubMed  Google Scholar 

  43. Strong DM, Friedlander GE, Tomford WW, Springfield DS, Shives TC, Barchardt H, Enneking WF, Mankin HJ (1996) Immunological responses in human recipients of osseous and osteochondral allografts. Clin Orthop 326: 107–114

    PubMed  Google Scholar 

  44. Takayama S, Hatsuda N, Matsumura K, Nakasu S, Handa J (1993) Creutzfeldt-Jakob disease transmitted by cadaveric durai graft: a case report. No Shinkei Geka 21(2): 167–170

    PubMed  Google Scholar 

  45. Urist MR, Mikulski AJ, Boyd SD (1975) A chemosterilized antigen extracted bone morphogenetic alloimplant. Arch Surg 110: 416–423

    PubMed  Google Scholar 

  46. Urist MR, Silverman BF, Büring K, Dubuc FL, Rosenberg JM (1967) The bone induction principle. Clin Orthop 53: 243–283

    PubMed  Google Scholar 

  47. Urist MR (1976) Practical applications of basic research on bone graft physiology. In: AAOS Instructional Course Lectures. The American Academy of Orthopedic Surgery, vol 25. Mosby, St Louis, pp 1–26

    Google Scholar 

  48. Urist MR (1968) Surface-decalcified allogenic bone (SDAB) implants. Clin Orthop 56: 37–50

    PubMed  Google Scholar 

  49. Urist MR (1992) Bone morphogenetic protein. In: Habal M, Reddi J (eds) Bone grafts and bone substitutes. Saunders Company, Philadelphia, pp 70–83

    Google Scholar 

  50. US Department of Health and Human Services (1988) Transmission of HIV through bone transplantation: case report and public health recommendations. MMWR 37: 597–599

    Google Scholar 

  51. van Putten MC Jr, Yamada S (1992) Alloplastic cranial implants made from computed tomographic scan-generated casts. J Prosthet Dent 68(1): 103–108

    PubMed  Google Scholar 

  52. Voggenreiter G, Ascherl R, Blumel G, Schmit-Neuerburg KP (1994) Effects of preservation and sterilization on cortical bone grafts. A scanning electron microscopic study. Arch Orthop Trauma Surg 113(5): 294–296

    PubMed  Google Scholar 

  53. Voggenreiter G, Ascherl R, Fruh HJ, Blumel G, Schmit-Neuerburg KP (1995) Preservation and sterilization of cortical bone: biomechanical studies of the rat. Unfallchirurg 98(2): 53–58

    PubMed  Google Scholar 

  54. Willison J (1989) Update: Creutzfeldt-Jakob disease in a second patient who received a cadaveric dura mater graft. MMWR Morb Mortal Wkly Rep 38(3): 37–38

    PubMed  Google Scholar 

  55. Yamada S, Aiba T, Endo Y, Hara M, Kitamoto T, Tateishi J (1994) Creutzfeldt-Jakob disease transmitted by a cadaveric dura mater graft. Neurosurgery 34(4): 740–743

    PubMed  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Head Division of Neurosurgery, Clinica Univeritaria, University of Navarra, Pamplona, Navarra, Spain

    V. Vanaclocha Ph.D., M.D.

  2. Consultant Division of Plastic Surgery, Clinica Univeritaria, University of Navarra, Pamplona, Navarra, Spain

    A. Bazan

  3. Junior Consultant Department of Anaesthesiology, Clinica Univeritaria, University of Navarra, Pamplona, Navarra, Spain

    N. Saiz-Sapena

  4. Head Division of Plastic Surgery, Clinica Univeritaria, University of Navarra, Pamplona, Navarra, Spain

    V. Paloma

  5. Consultant Department of Pathology, Clinica Univeritaria, University of Navarra, Pamplona, Navarra, Spain

    M. Idoate

Authors
  1. V. Vanaclocha Ph.D., M.D.
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. A. Bazan
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. N. Saiz-Sapena
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. V. Paloma
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. M. Idoate
    View author publications

    You can also search for this author in PubMed Google Scholar

Rights and permissions

Reprints and permissions

About this article

Cite this article

Vanaclocha, V., Bazan, A., Saiz-Sapena, N. et al. Use of frozen cranial vault bone allografts in the repair of extensive cranial bone defects. Acta neurochir 139, 653–660 (1997). https://doi.org/10.1007/BF01412001

Download citation

  • Issue Date:

  • DOI: https://doi.org/10.1007/BF01412001

Keywords

Search

Navigation