ISSN:
0003-3146
Keywords:
Chemistry
;
Polymer and Materials Science
Source:
Wiley InterScience Backfile Collection 1832-2000
Topics:
Chemistry and Pharmacology
,
Physics
Description / Table of Contents:
The aim of the studies was to characterize the ultrafiltration properties of a variety of photochemically modified membranes, made by a new approach starting with two types of PAN-UF membranes and using nine aromatic azides bearing different more or less hydrophilic or hydrophobic substituents. The influence of the surface functionalization (hydrophilization, introduction of charges/hydrophobization) realized by this means onto the water permeability, the dextrane selectivity, and the permeabilities during and after UF, resp., after simple contact with solutions of ovalbumine and lysozyme was the major subject. Modified membranes made using the aryl azides with hydrophilic groups, 4-azidobenzoic acid, Ib, (4-azidophenyl)trimethylammonium iodide, If, sodium (4-azido)-benzene sulfonate, Id, showed enhanced water fluxes and reduced dextrane retention. All the other azides caused reduced water permeability, enhanced dextrane selectivity, and significant flux reductions as a consequence of contact with ovalbumin solutions (pH = 5.0). The strongest effects were achieved with the two expecially hydrophobic compounds, 2-naphthyl azide, Ih, and 2-naphthoyl azide, IX. On the other hand, a pronounced positive effect of photo-modification on the protein fouling behaviour became evident in the UF of lysozyme (0.05%, pH = 10.5). Using the membranes modified with Id a much higher filtrate flux (Jv = 48.1 l/m2h) was observed as compared with the original PAN membrane (Jv = 13.1 I/m2h). The perspectives and the limitations of the developed modification strategy are discussed.
Notes:
Nach einem neuartigen Verfahren mit Hilfe von neun, mit verschieden hydrophilen bzw. hydrophoben Substituenten synthetisierten aromatischen Aziden unterschiedlich photochemisch modifizierten Polyacrylnitril-Ultrafiltrations-Membranen wurden in UF-Versuchen charakterisiert. Dabei sollte der Einfluß der so erzielten Oberflächenfunktionalisierungen (Hydrophilierung, Einführung von Ladungen oder Hydrophobierung) auf das Trennverhalten (Wasserdurchläassigkeit und Selektivitäat für Dextrane, Permeabilität während und nach der UF bzw. nach einfachem Kontakt mit Ovalbuminund mit Lysozym-Lösungen) studiert werden. Die Modifizierung mit den Arylaziden, die hydrophile Gruppen enthalten (4-Azidobenzoäure, Ib, (4-Azidophenyl)-tri-methylammoniumiodid, If, Natrium-4-azidobenzolsuflfonat, Id), führt zu einer erhöhten Durchlässigkeit der Membranen für Wasser und Dextrane. Alle anderen Azide, darunter besonders stark die deutlich hydrophoben 2-Naphthoylazid, Ih, und 2-Naphthoylazid, IX, verringern die Wasserpermeabilität, erhöhen das Rückhaltevermögen für Dextrane und verstärken die Effekte der Wechselwirkungen mit Ovalbumin (pH = 5,0). Das wird in Flußreduzierungen verglichen mit der unmodifizierten PAN-UF-Membran sichtbar. Ein positiver Effekt der Photomodifizierung wird besonders deutlich bei der UF von Lyasozym (0,05%, pH = 10,5) mit der mit Id modifizierten Membran (Jv = 48,1 l/m2h) im Vergleich zur Ausgangs-Membran (Jv = 13,1 1/m2h). Die Perspektiven und die Grenzen des Modifizierungsverfahrens werden abschließend diskutiert.
Additional Material:
6 Ill.
Type of Medium:
Electronic Resource
URL:
http://dx.doi.org/10.1002/apmc.1993.052100108
Permalink